IndiaBizClub Login

x Register Free
x Register Free

PLI, LLC

J

PLI, LLC

MEMOLUB Lubricator - The Memo System

Guangzhou



A Quality Product from
PLI, LLC [View Profile]
GuangZhou -

Description :
The MEMO regulates the rate of grease output of the MEMOLUB? HPS. It consists of a brass adapter, a black plastic timing-ring holder, and three plastic timing rings (one white, one red, and one black). The MEMO is permanently fitted onto the bearing or other component, and all MEMOLUB? HPS lubricators of any size will recognize its program setting.

The brass adapter is an extension of the MEMOLUB's pump cylinder. One end has a short ?” NPT thread used to mount the MEMO on the bearing. The other end is an M12x1.50 thread that screws into the MEMOLUB? lubricator. A set of special stroke-limiting washers is supplied with each MEMOLUB? for use in programming the volume of lubricant ejected on each output cycle.

When the MEMO is used without washers (yielding full piston stroke), the output volume at each stroke is 0.635cc. For each washer inserted into the brass adapter of the MEMO, the output volume will decrease by 0.04cc per stroke. A Maximum of 8 washers (including a lock washer) can be inserted into the brass adapter. If the stroke-limiting washers are used, the lock washer should be inserted last to hold the others in place. If only one washer is used, use the locking washer. Important Note: When using the 2-Point Splitter volumetric setting is not possible.

The white, red, and black plastic timing rings are used to set the frequency of ejection cycles of the MEMOLUB? HPS. They are inserted into the black plastic ring-holder either individually or in combination to obtain the desired frequency of output cycles.

Using the volumetric program settings described above, and the frequency settings shown, it is possible to achieve 52 different rates of lubricant output. The output settings are shown on in our "Installation Instruction" sheets under "Basic Program Settings” and "Fine Tuning Your Lubrication Program”.


View Complete Catalog





PLI, LLC

Manufacturers of all types Plants and know intimately the equipment and problems our customers encounter. Our Products : MEMOLUB Lubricator - The Memo System - Replacement Kits - Hazardous Locations - 2-Point Splitter Systems - Multi-Point Systems Power Options : - EPC (External Power Control) - EPS (External Power Source) 4.5V, 12V & 24V - 24 VDC PLC-Control - Full Control Installation Parts & Accessories : - Push-in tube fittings - Compression fittings - Tubing, Empty or Pre-Filled with lubricant. - Mounting Brackets & Dust Covers - Chain Oil Brush Assemblies - Adapters & Check Valves - Power Supplies & Transformers - Wire Extension Kits - Housing Kits



View Company Profile

Other Matching Products


Multipoint Lubricator

These types of lubricators are fitted on a machine suitable and are connected to the lubrication point by means of welded/seamless steel tubes, rubber hoses and compression type fi ....

LM GUIDE LUBRICATOR QZ

Maintenance intervals can be greatly extended. In the case of lubricating ball screw with ordinary grease, a small amount of grease is lost during the course of travel. Installati ....

BALL SCREWS LUBRICATOR QZ

Maintenance intervals can be greatly extended. In the case of lubricating ball screw with ordinary grease, a small amount of grease is lost during the course of travel. Installati ....

Miniature Pneumatic Air Filter

Manufacturer and exporter of Pneumatic Spares. Other Shavo Products :- Miniature Pneumatic Air Filter Miniature Pneumatic Pressure Regulator Miniature Pneumatic Micro-Fog Lub ....

Lubricator

The BLG-30 Lubricator is intended for the lubrication at compressed air driven machine designed for a working pressure of 10 kg/cm2 (142 psi), the lubricator can be used with an ai ....

RLA Services

IEPC Conduct energy audit shall look into the heat balances and mass balances of the unit including coal, oil, water, chemicals and auxiliary power consumptions, visit site assess ....

Air Lubricator

This Lubricator Consists Of Aluminium Body Construction with Buna-n- Seals, With Transparent Shutter Proof Polycarbonate Bowl Or Metal Bowl. Fine Oil feel permits right amount of ....

Air Lubricator

This Lubricator Consists Of Aluminium Body Construction with Buna-n- Seals, With Transparent Shutter Proof Polycarbonate Bowl Or Metal Bowl. Fine Oil feel permits right amount of ....

Air Line Lubricators

MDS 201 Airline Lubricator is designed to provide adequate lubrication to Pneumatic Tools which is very much essential for their efficient working and upkeep its performance. MDS l ....

Air Line Lubricators

The BLG-30 Lubricator is intended for the lubrication at compressed air driven machine designed for a working pressure of 10 kg/cm2 (142 psi), the lubricator can be used with an ai ....



Business Blog About Us Support Contact Sitemap Privacy Policy Terms & Conditions

© Copyright 2000 - 2017 IndiaBizClub. All rights reserved.